New Morgan-tec muffler & dual exhaust

[Kenny]

New Morgan-tec SS muffler (polished ). This muffler is a work of art and built like a tank. The guys at the shop were quite impressed (thanks again Mike!)

2.25" inlet and 2x 2.5" outlets. No extra baffling.

It's tied-in right after the stock "Y" from the cats. I'm thinking of replacing the cats and re-do the piping and O2 sensors later.

Sorry I didn't get "before" pictures.





Re-used existing rubber mounts.




NEW DUALS!
and new tips- 2.5" - 3.25" - Single walled, rolled edge, oval.




Up and over and around the gas tank. The 912 lift gave oodles of room.




one piece:



two piece:





I had them place the tips recessed so they would be less prone to dissapearing on moab trails (a la Tone )




Unfortunately, to get the look, I lost the ability to use my shackle.



..and the sound clip:
http://www.vehicross.info/gallery/sh...cat=500&page=1

keep in mind that it's only 3 days old - I'll post another in a month to see how much it "matured".


and yes, I have a red paint fetish.

Cheers, eh.

[biju]

Looking good. Keep up the great mods!

p.s. - do you mind if I ask how much this set you back to get installed?

-biju.

[Kenny]

Looking good. Keep up the great mods!

p.s. - do you mind if I ask how much this set you back to get installed?

-biju.

~$80 for muffler.(super worth it!)
~$250 for install and parts.
Will be another ~$150 to do the piping between the cats and muffler (O2 sensors are there and a flex pipe). +cost of new cats.

I found a little "dad and son" shop with lots of experience - came highly recommended by the local speed shops. I basically told them to take the time and parts to do it right and then give me a bill. I'm quite happy, and I think I got a good job done...

[djkymar]

really nice work!
question if i dont have supercharge does it make any improvments if i put dual exhaust like that?

[WormGod]

really nice work!
question if i dont have supercharge does it make any improvments if i put dual exhaust like that?

And to add to that question, how does it affect an existing S/C?

Any info on emissions with this exhaust?

[Cyrk]

Looks and sounds good!

[Kenny]

really nice work!
question if i dont have supercharge does it make any improvments if i put dual exhaust like that?

From what I understand, this set-up will not make too much of a noticeable difference in power (I don't notice anything myself - other than sound). I do plan to get a S/C in spring, so my hope was that this will help the S/C exhaust better. But I think the optimal compliment to a S/C is to maybe lose the cats and go with TWO smaller mufflers, one on each header pipe - true duals (Tone pointed this out to me and would have much more info on this).

And to add to that question, how does it affect an existing S/C?

Any info on emissions with this exhaust?

Yes, I'd like to find some dyno results on the board here to see any before and after S/C with stock exhaust - then aftermarket muffler & duals. I'm curious myself.

As for emissions, most provinces here don't regulate them. Sorry, can't help you there. But curious too.


Right now for me, any notable performance increase would be a bonus as I was going for the look of duals, a more agrressive "growl", and a tough cool muffler. But come the S/C, if a better setup can add a noticeable amount of hp - I may consider it, so long as it's not crazy loud.

[Ldub]

Beauty EH ?!!!

[Bieredalsace]

Beautiful job~!!!!!!!

[LittleBeast]

Beautiful job~!!!!!!!

20 months late